|本期目录/Table of Contents|

[1]彭文强,杨帅强,石国芳,等.油泥中原油回收的实验研究[J].武汉工程大学学报,2010,(03):1-4.
　PENG Wen qiang,YANG Shuai qiang,SHI Guo fang,et al.Experimental study on technology of oil recovery from oily sludge[J].Journal of Wuhan Institute of Technology,2010,(03):1-4.
点击复制

油泥中原油回收的实验研究(/HTML)
分享到：

《武汉工程大学学报》[ISSN:1674-2869/CN:42-1779/TQ]

卷:
期数:
2010年03期
页码:
1-4
栏目:
化学与化学工程
出版日期:
2010-03-31

文章信息/Info

Title:
Experimental study on technology of oil recovery from oily sludge
文章编号:
16742869(2010)03000104
作者:
彭文强1; 杨帅强1; 石国芳1; 2; 沈喜洲1*; 薛松1; 丁陈斌1
1.武汉工程大学化工与制药学院，湖北 武汉 430074； 2.荆州职业技术学院，湖北 荆州 434020
Author(s):
PENG Wenqiang1; YANG Shuaiqiang1; SHI Guofang2; SHEN Xizhou1;  XUE Song1;  DING Chenbin1
1.School of Chemical Engineering and Pharmacy, Wuhan Institute of Technology, Wuhan 430074，China；
2. Jingzhou Institute of Technology, Jingzhou 434020, China
关键词:
含油污泥; 化学处理; 回收率
Keywords:
oily sludge;  chemical treatment;  recovery rate of treated sludge
分类号:
TE992.3
DOI:
-
文献标志码:
A
摘要:
选用分离剂YH、YC、YE和YS（由武汉工程大学化工与制药学院石油炼制实验室自制）对含油污泥进行处理，回收油泥中的原油并进行了复配实验.考察了搅拌速度、剂泥比、搅拌时间、温度等工艺条件对回收率的影响.实验结果表明：单独使用四种分离剂时，YH处理油泥后回收率最高，其次为YE，再次为YC,YS的回收率最低,YH、YC和YE复配的分离效果优于单剂.最佳的复配比例为：YH 的质量分数为1%，YC的质量分数为1.5%，YE的质量分数为5%，其余为水.最佳的工艺条件为：搅拌速度为1 000 r/min，剂泥比3∶1，搅拌时间40 min，温度为40 ℃.在最佳条件下，回收率可达86.9%.
Abstract:
Oily sludge was treated by YH、YC、YE and YS as separation agents to recovery oil in this paper. The remixing experiment and the effect of agitation speed, agents/sludge ratio, agitation time, temperature,etc. on the recovery rate of treated sludge was studied.The experimental results indicated that the effects of sludge treating are that YH is the best,YC is better than YE, and YS is the worst,the effect of remixing is better than any other agents. The optimal efficiency of oily sludge treating is achieved when YH is 1%,YC is 1.5% and YE is 5%. The best technological conditions are that agitate intensity is 1 000 r/min, agents/sludge ratio is 3∶1, agitate time is 40 minutes and temperature is 40℃, the recovery rate of treated sludge is 86.9% in best conditions.

参考文献/References:

1］Athanasios K K, Evangelos A V. Anion Leaching from Refinery Oily Sludge and Ash from Incineration of Oily Sludge Stabilized/Solidified with Cement. Part I. Experimental Results［J］. Environ Sci Technol, 2008, 42 (16):61166123.
［2］Ahmed A F, Ahmad J, Basma Y,et al. Assessment of alternative management techniques of tank bottom petroleum sludge in Oman［J］. Journal of Hazardous Materials,2007,141:557564.
［3］Mait K，Marcia M，Aleksander M. Characterization of oily sludge from a wastewater treatment plant flocculation–flotation unit in a petroleum refinery and its treatment implications［J］.J Mater Cycles Waste Manag,2008,10:7986.
［4］Fadhil M S, Avin E P, Kirthi J.Levels of radium in oily sludge［J］.International Journal of Environmental and Analytical Chemistry,2005,85(2):141147.
［5］车承丹，吴少林，朱南文，等.含油污泥石油醚浸提技术研究［J］.安全与环境学报,2008，8(1)：5658.
［6］包木太，王兵，李希明，等.含油污泥生物处理技术研究［J］.自然资源学报,2007，6（22）：855871.
［7］李一川，王栋,王宇，等.热化学清洗法洗涤油泥—回收石油的工艺条件研究［J］.环境污染与防治,2008，30（3）：3942.
［8］罗立新. 油田含油污泥浓缩工艺研究［J］.石油与天然气化工，2007，4（36）：344346.
［9］Madar I， Juriga M.A new method of the organic wasye teatment,concerning waste oil mixed plastics waste,oil sludge and pcbs waste processing with simultaneous recoverry of hydrocarbons［J］.Pertroleum and Coal,2003,4(45):187192.
［10］刘玉丽.油田含油污泥焚烧处理技术及设备研究［J］.石油与天然气化工,2005，5（34）：426428.

相似文献/References:

[1]沈喜洲１,２,王道楠２,等.渤海油田含油污泥处理效果的改进[J].武汉工程大学学报,2015,37(06):1.[doi:10. 3969/j. issn. 1674-2869. 2015. 06. 001]
　,,et al.Ｅｘｔｒａｃｔｉｏｎ ｔｅｃｈｎｏｌｏｇｙ ｏｆ ｐｒｏｔｅｉｎ ｆｒｏｍ ｂａｓｅ ｏｆ Ｆｌａｍｍｕｌｉｎａ ｖｅｌｕｔｉｐｅｓ[J].Journal of Wuhan Institute of Technology,2015,37(03):1.[doi:10. 3969/j. issn. 1674-2869. 2015. 06. 001]

备注/Memo

备注/Memo:
收稿日期：20090902作者简介：彭文强（1986），男，湖北汉川人，硕士研究生.研究方向：石油化工.指导老师：沈喜洲，教授级高工，硕士研究生导师.研究方向：化学工程、石油化工.
更新日期/Last Update: